Open AccessMATHEMATICAL MODELING OF INFLUENCE THE OPERATION MODE DIESEL ENGINE ON THE CONTENT OF PARTICULATE MATTER IN EXHAUST GASES
Author(s) -
A. Polivyanchuk
Publication year - 2020
Publication title -
komunalʹne gospodarstvo mìst
Language(s) - English
Resource type - Journals
eISSN - 2522-1817
pISSN - 2522-1809
DOI - 10.33042/2522-1809-2020-3-156-62-68
Subject(s) - diesel fuel , diesel engine , particulates , diesel exhaust , environmental science , work (physics) , automotive engineering , diesel particulate filter , exhaust gas , chemistry , mechanics , thermodynamics , engineering , physics , organic chemistry
The work is devoted to solving an urgent scientific and practical task – establishing mathematical models that describe the effect of operating modes of diesel engines on the content in the exhaust gases of a dangerous pollutant – particulate matter (PM). The purpose of the work was to create and study the accuracy and practical suitability of the calculation method estimating concentrations and emissions with exhaust gases PM by means of mathematical modeling of the influence on them of parameters that determine steady state and unsteady diesel operation modes. The studies were carried out on the basis of the motor stand of a 4ChN12/14 autotractor diesel equipped with a partial-flow system for diluting EG with air – MKT-2 microtunnels. Measurements mass and vol-ume concentrations – cpt (g/kg) and Cpt (g/mn3), mass – PTmass (g/h) and specific – PTp (g/kWh) PM emissions was carried out by the gravimetric method with errors of ± 3 .. 10% in accordance with the requirements of regulatory documents – ISO8178 standard, UNECE Rules R-49, R-96, etc. As parameters which determine the mode of opera-tion of the diesel engine, were considered: during the study steady-state modes – the number of revolutions of the engine crankshaft (n, min-1) and the load (L,%); in the study of unsteady modes – the parameters n and L and the rate of change over time – Δn/Δt and ΔL/Δt. A dependence has been established for indirectly determining the mass concentration of PM in the exhaust gases at steady and unsteady diesel operating modes, which are charac-terized by a duration of 10 ... 30 s and ranges of vari-ation of the parameters n, L, Δn/Δt and ΔL/Δt, given in di-mensionless form: 0.4 ... 0.8, 0.3 ... 1.0, -0.2 ... 0.2 and -0.35 ... 0.35, respectively. The deviation of the calculated and experimental data when using this dependence is ± 0.005-0.006 g/kg, which is comparable with the sensitivity limit of MKT-2.Keywords: diesel, exhaust gases, particulate matter, concentration, test mode, mathematical model, accuracy.