Premium
Residues from the dairy industry as co‐substrate for the flexibilization of digester operation
Author(s) -
Hubert Christian,
Steiniger Bettina,
Schaum Christian
Publication year - 2020
Publication title -
water environment research
Language(s) - English
Resource type - Journals
SCImago Journal Rank - 0.356
H-Index - 73
eISSN - 1554-7531
pISSN - 1061-4303
DOI - 10.1002/wer.1197
Subject(s) - biogas , pulp and paper industry , context (archaeology) , anaerobic digestion , effluent , resource recovery , chemical oxygen demand , slurry , environmental science , chemistry , wastewater , waste management , methane , environmental engineering , engineering , paleontology , organic chemistry , biology
Water resource recovery facilities (WRRF) can make an important contribution to increase the share of renewable energies in Germany. In this context, it is important to utilize unused digester capacities on WRRF. In addition, a demand‐orientated biogas production could synchronize electricity demand and electricity generation and improve the overall energetic balance of the WRRF. As part of the project “Water Resource Recovery Facilities in interaction with the waste and energy industry: A German‐Austrian Dialogue – COMITO,” the influence of residues from the dairy industry on the digestion process was examined as well as the suitability for the flexibilization of digester gas production. Four reactors were fed with different amounts of flotation sludge from the dairy industry for several months. The difference in the feed resulted in organic loading (OLR) rates between 3.2 kg COD/(m 3 day) and 6 kg COD/(m 3 day). The reactors were fed with a daily shock load. The investigations showed that volumetric loads up to 4.4 kg COD/(m 3 day) did not lead to an accumulation of organic acids. Organic loading rate of 6 kg COD/(m 3 day) showed a significant accumulation of organic acids higher than 2,500 mg/L oHAc. Nevertheless, the reactor could be operated with a degradation rate of 71% with a corresponding biogas yield with a methane content of 71%. With increasing flotation sludge content, a higher concentration in ammonium of up to 2.000 mg/L NH 4 ‐N could be detected in the effluent of the digester. Despite higher phosphorus concentration in the flotation sludge, the concentration of PO 4 ‐P remained constant for all reactors fluctuating between 20 and 40 mg/L PO 4 ‐P. Dewatering worsened significantly with increasing levels of flotation sludge. Practitioner points Main purpose of the research is to flexibilize digester operation on WRRF using flotation sludges from the dairy industry. Flexibilization of the digester using flotation sludge is possible up to an organic load of 6 kg COD/(m 3 day). Higher NH 4 ‐N concentration in the effluent of the digester must be accepted when using higher amounts of flotation sludge. Phosphate concentration in the effluent of the digester remained on a low level despite higher phosphorus content in the flotation sludge. High levels of organic acids (mainly acetic acid) can be tolerated and can be recovered within a short time after reducing the load.